Autoblog

General Motors has nixed an optional hot-spray windshield washer system called HotShot from all of its cars and trucks after an electrical short in the systems caused the recall of 944,000 vehicles. GM told the National Highway Traffic Safety Administration that a short on the circuit board of the fluid heater could overheat the control-circuit ground wire. The problem has resulted in 34 warranty claims so far and three reports of fires may have been caused by the system. To fix the problem, dealers will add a wiring harness with an inline fuse, and all GM retail outlets should have the required parts to fix the problem free of charge by November 1. Vehicles affected include the Buick Lucerne and Enclave, the Cadillac DTS and Escalade, the GMC Yukon, Sierra and Acadia, the Saturn Outlook, the Hummer H2, and the Chevy Silverado, Avalanche, Tahoe, and Suburban.

GM blames the system's suburban Detroit supplier, Microheat, for the problem, and the small company has reportedly shrunk in size in preparation of forever closing its doors. The General wants Microheat to pay for the recall, which is estimated to cost between $20 and $25 million, and the small supplier has countered by reminding the automaker that it's still owed $3.7 million for parts and tooling. The whole affair is a shame, as heated windshield washer fluid is a nice luxury that makes de-icing and de-bugging your windshield a hands-off affair. As far as we know, Microheat is the only supplier offering this technology, so when it goes, so does the option altogether.

[Source: Automotive News, sub. req'd]

In the ongoing quest to make our cars more user-friendly, automakers have been adding more and more techno-goodies to make our lives just a bit easier, as well. Unfortunately, these features occasionally do the exact opposite as electrical gremlins take control and make them malfunction. Such is the case with a 857,735 vehicles from General Motors built between 2006 and 2008 that are equipped with heated windshield washer fluid. Apparently, the system is liable to short out, causing it to stop working and even smoke, give off an odor, and make other on-board electronic systems go haywire. To remedy the problem, dealers will add a new wiring harness with an in-line fuse, which will short out before the problematic printed electrical circuit does the same. We've pasted a list of all the affected vehicles after the break.

[Source: NHTSA via Good Car Bad Car]

Click above for high-res gallery of the 2009 Jaguar XF

If you have a 2009 Jaguar XF, you should hop down to your dealer to have the rear safety belt assembly looked at. Jaguar is recalling 7,900 of the '09 cars because in an accident the rear occupants might not be properly restrained. To find out more you can call Jaguar at 1-800-452-4827, or make an appointment at your local Jaguar dealer.


[Source: Carscoop]

Some 2008-model Hyundai Elantras are being recalled due to fuel pumps that could lose pressure and decreasing engine performance. In Elantras with the 2.0-liter Beta engine, gasoline with ethanol added creates a buildup of film on the pump's electrical contacts. This can cause the engine to hesitate during starting or while running. The recall is voluntary, and if you have one of the affected cars, don't hesitate to contact your dealer.

[Source: Freep]

All owners of 2008 Honda Elements are being asked to stop driving their cars until they have had them inspected at their local Honda dealer. According to a recall issued by the National Highway Traffic Safety Administration, the front bushing bracket of the left trailing arm of the rear suspension may have been improperly welded. If it fails, it could separate from the trailing arm causing the suspension to release part of the wheel hub, thus leading to a loss of control or crash. Although only 241 Elements are potentially affected (there are specific VIN number ranges during certain production dates), Honda is notifying all owners immediately and will inspect and replace defective parts at no charge. Rather than taking a risk, err on the side of safety and call your Honda dealer if you've got the keys to a 2008 Element in your pocket.

UPDATE: According to Honda spokesman Chris Martin all the affected owners were already notified before this story was published. Approximately half of the affected vehicles were unsold and sitting on dealer lots. Those have already been repaired. If you haven't already heard from Honda than you should be fine.

[Source: NHTSA via Carscoop]

Click on the image above for our high-res 2008 WRX STI gallery

Subaru of America announced a service campaign this week focused on the 305-hp turbocharged 2.5-liter four powering the 2008 WRX STI. According to the verbiage on a letter sent to an owner, Subaru states that "abnormal combustion" could occur when the engine is repeatedly or continuously operated above redline (6,700 rpm). At these high engine speeds, the Engine Control Module cuts fuel to the powerplant to protect the engine from even higher revolutions (this is common industry-wide, not just with Subaru). Unfortunately, under certain situations the Subaru 4-cylinder Boxer is still under high boost and the fuel cut-off causes the engine to run "over lean" resulting in combustion that breaks piston ring lands... eventually destroying the engine.

Subaru's "Service Program Campaign WVE15" reprograms the Engine Control Module software to improve combustion at engine speeds above redline, preventing engine damage. Subaru is quick to point out that the revised programming "will not adversely affect the peak performance" of the vehicle, so owners need not worry about the free campaign messing up their 0-60 sprints. Letters from Subaru will go out to owners in the next week or two. In the meantime, try keeping the white needles out of the red zone!

[Source: IWSTI]

Way back in February, the NHTSA began investigating certain full-size trucks and SUVs from General Motors for the possibility of their engines spontaneously combusting, even when the ignition key is in the 'off' position. At that time, the investigation covered some 423,000 vehicles, and GM seemed pretty confident that the issue would not be widespread. Yeah, it appears as if the General was a little off in that assessment. The engine fire issue may now affect about 2.7 million vehicles, including all of the latest Chevrolet, GMC and HUMMER full-size models.

A preliminary examination of the electric systems throughout these vehicles is being conducted at this time. Depending on the results of the NHTSA's 'Engineering Analysis', a recall could follow. So far, there exists 41 reported cases of non-crash-related underhood fires, with 16 of those supposedly with the ignition turned off. Check after the jump for a complete list of all the possibly affected vehicles.

[Source: Consumer Affairs]

Click above for high-res gallery of the 2008 Dodge Journey

Chrysler is recalling 6,692 Dodge Journey crossover vehicles equipped with its 3.5L V6 engine due to a wiring harness problem that could potentially result in an engine fire. NHTSA says the issue can occur when the wiring harness becomes dislodged and makes contact with the transaxle mount. Effected vehicles need to be checked out at your local Dodge dealer where the wiring harness will be inspected for damage. If the harness is damaged it will be replaced, and all harnesses will be secured with a tie wrap to ensure the issue doesn't reoccur. Chrysler has known about the issue since mid-March, but no actual fires have been reported as of this time.

The Journey recall is the second NHTSA action on a new vehicle this month, the Volkswagen Tiguan being the other, with each model having less than 7,000 units effected. Though nobody wants to see a time-consuming recall, it's good to see that issues are being discovered well in advance of any freeway carbeques.

[Source: Inside Line]

Click above for high-res gallery of the Volkswagen Tiguan

Volkswagen is recalling 4,000 2008 Passats and 2009 Tiguans for an "engine surging" issue. The problem is an engine control module that may not control engine idle when the air conditioning is turned on. In rare cases, the ECM can trigger an unexpected jump in engine RPM, which could obviously lead to an accident. NHTSA has informed VW that since the recall is a safety concern, dealers cannot sell the vehicles until the problem has been fixed. Owners of potentially affected vehicles are being told not to operate the air conditioning until a VW dealer has serviced the ECM, which is less than terrific news considering it's June and temperatures are around 90 degrees in many parts of the country. While it's disheartening that the brand new Tiguan is already getting its first recall, at least the problem was discovered early and there's a fix readily available.

[Source: Inside Line]

Even after recalling 10 million vehicles over the past few years, Ford just can't seem to shake the cruise control blues. There have been 130 reports of fires in 1998-2003 Ford Windstars, both during use and while parked, and the NHTSA is looking into the matter to determine if a recall is needed. The fires may be due to the Windstar's cruise control system, but Ford says this unit is different from the system that caused the 10 million-unit recall because it isn't powered at all times, and it doesn't pose a risk. If the Windstars are recalled, over 1.7 million minivans will be affected.

[Source: Autoweek]